Impact of GST on the Cement Industry

Cement will attract 28% GST, i.e., a higher rate of tax which means increased costs for the infrastructure sector.

Refractory cement, mortars, concretes (mainly used for building industry furnaces, huge ovens etc.) will attract 18% tax.

Cement Bonded Particle Board will attract 12%.

The main raw materials for cement are limestone, coal and electricity. The tax rates on these are as follows:

  •        Limestone is taxed at 5%
  •        Coal is capped at 5%,which is a reduction from the earlier rate of 11.69%
  •        Electricity is outside the purview of GST
  • Nothing is mentioned regarding the royaltythat the cement companies pay to the state governments for quarrying limestone. Clean energy cess is levied on coal, which is not available as an input credit because it is not subsumed by GST.
  • So, these two factors will continue to be outside the purview of GST and will be included in the cost of the cement production even after GST is implemented, as was done previously.

 

Positive Impact of GST on Cement Industry

 

Warehousing

Cement manufacturers can heave a sigh of relief as the supply chain management of cement will get a boost under GST. Most companies maintain multiple warehouses across states to avoid CST and state entry taxes. These warehouses generally operate below their capacity which leads to operational inefficiencies. Like other sectors, the cement companies will also consolidate their warehouses and maintain warehouses in areas where it is most beneficial (such as Nagpur-0-mile city) thus leading to operational economies.

 

Savings on Transport Costs

Most of the cement manufacturers are located near limestone quarries. But demand for cement is pan-India which means that the cost of transporting cement from the manufacturer to the buyer is pretty high. Now, with GST the logistics industry is also going to be overhauled. The transit time will decline as vehicles will spend lesser time at checkpoints. This will lead to lower transportation costs and in turn, the cement industry will save transport costs.

 

Less Complex Taxes

Currently, there are multiple excise duties applicable to cement manufacturers. There are separate rates and specific duties applicable on different types of cements depending on whether they are supplied in bulk form or in packaged form, or whether they are for industrial or trade purposes etc.

 

 

 

Conclusion

All these put together may reduce the operating costs for the cement industry in the future. However, reduction in costs for the end-consumer will occur only if the cement companies pass on their savings to the consumers. Till then, it is expected that prices of cement will increase, at least temporarily, once GST is implemented. In turn, costs for infrastructure and housing which are highly dependent on cement, will also increase.